12M Series 3, 140M Series 3, 160M Series 3, 140, 150 and 160 Motor Graders Diagnostic Trouble Codes Caterpillar


Diagnostic Trouble Codes
`
1.1. Component Identifier (CID) and Failure Mode Identifier Information

The following is a list of Diagnostic Trouble Codes (DTCs) for the 12M3, 140M3, 160M3 Machines. When a diagnostic code becomes active, refer to the Troubleshooting section of this manual for a specific troubleshooting procedure.

Component Identifier (CID) and Failure Mode Identifier Information

Table 1
Transmission ECM (MID 27) 
DTC  Description  Procedure 
41-3  8 VDC Supply: Voltage Above Normal  Sensor Supply - Test 
41-4  8 VDC Supply: Voltage Below Normal  Sensor Supply - Test 
70-3  Parking Brake Switch: Voltage Above Normal  Switch Circuits - Test 
70-4  Parking Brake Switch: Voltage Below Normal  Switch Circuits - Test 
96-3  Fuel Level Sensor: Voltage Above Normal  Sensor Signal (Analog, Passive) - Test 
96-4  Fuel Level Sensor: Voltage Below Normal  Sensor Signal (Analog, Passive) - Test 
127-3  Transmission Oil Pressure Sensor: Voltage Above Normal  Sensor Signal (Analog, Active) - Test 
127-4  Transmission Oil Pressure Sensor: Voltage Below Normal  Sensor Signal (Analog, Active) - Test 
127-8  Transmission Oil Pressure Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (Analog, Active) - Test 
168-2  Electrical System Voltage: Data Erratic, Intermittent, or Incorrect  Electrical Power Supply - Test 
168-3  Electrical System Voltage: Voltage Above Normal  Electrical Power Supply - Test 
168-4  Electrical System Voltage: Voltage Below Normal  Electrical Power Supply - Test 
177-3  Transmission Oil Temperature Sensor: Voltage Above Normal  Sensor Signal (Analog, Passive) - Test 
177-4  Transmission Oil Temperature Sensor: Voltage Below Normal  Sensor Signal (Analog, Passive) - Test 
247-9  SAE J1939 Data Link: Abnormal Update Rate  CAN Data Link - Test 
247-14  SAE J1939 Data Link: Special Instruction  CAN Data Link - Test 
248-9  Cat Data Link: Abnormal Update Rate  Cat Data Link - Test 
248-14  AVS Data Link: Special Instruction  Cat Data Link - Test 
262-3  5 VDC Sensor Power Supply: Voltage Above Normal  Sensor Supply - Test 
297-9  All Wheel Drive Control: Abnormal Update Rate  Cat Data Link - Test 
297-14  All Wheel Drive Control: Special Instruction  Cat Data Link - Test 
368-3  Transmission Auto/Manual Switch: Voltage Above Normal  Operator Control Switch (Switch To Ground) - Test 
368-4  Transmission Auto/Manual Switch: Voltage Below Normal  Operator Control Switch (Switch To Ground) - Test 
420-3  Secondary Steering Relay: Voltage Above Normal  Relay - Test 
420-5  Secondary Steering Relay: Current Below Normal  Relay - Test 
420-6  Secondary Steering Relay: Current Above Normal  Relay - Test 
444-3  Starter Motor Relay: Voltage Above Normal  Relay - Test 
444-5  Starter Motor Relay: Current Below Normal  Relay - Test 
444-6  Starter Motor Relay: Current Above Normal  Relay - Test 
573-3  Inching Pedal Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
573-4  Inching Pedal Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
573-8  Inching Pedal Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
585-2  Transmission Output Speed Sensor #1: Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
590-9  Engine Control Module: Abnormal Update  Cat Data Link - Test 
590-14  Engine Control Module: Special Instruction  Cat Data Link - Test 
596-9  Implement Control: Abnormal Update Rate  Cat Data Link - Test 
596-14  Implement Control: Special Instruction  Cat Data Link - Test 
615-2  Machine Articulation Angle Sensor: Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
615-3  Machine Articulation Angle Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
615-4  Machine Articulation Angle Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
615-8  Machine Articulation Angle Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
615-13  Machine Articulation Angle Sensor: Out of Calibration  Sensor Signal (PWM) - Test 
615-14  Machine Articulation Angle Sensor: Special Instruction  Sensor Signal (PWM) - Test 
621-3  Downshift Switch: Voltage Above Normal  Operator Control Switch (Switch To Ground) - Test 
621-4  Downshift Switch: Voltage Below Normal  Operator Control Switch (Switch To Ground) - Test 
622-3  Upshift Switch: Voltage Above Normal  Operator Control Switch (Switch To Ground) - Test 
622-4  Upshift Switch: Voltage Below Normal  Operator Control Switch (Switch To Ground) - Test 
623-3  Directional Switch: Voltage Above Normal  Operator Control Switch (Switch To Ground) - Test 
623-4  Directional Switch: Voltage Below Normal  Operator Control Switch (Switch To Ground) - Test 
669-2  Transmission Input Speed Sensor: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
673-2  Transmission Output Speed Sensor #2: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
674-2  Transmission Intermediate Speed Sensor #1: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
675-2  Transmission Intermediate Speed Sensor #2: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
681-3  Parking Brake Solenoid: Voltage Above Normal  Solenoid Valve - Test 
681-5  Parking Brake Solenoid: Current Below Normal  Solenoid Valve - Test 
681-6  Parking Brake Solenoid: Current Above Normal  Solenoid Valve - Test 
740-3  Differential Lock Solenoid: Voltage Above Normal  Solenoid Valve - Test 
740-5  Differential Lock Solenoid: Current Below Normal  Solenoid Valve - Test 
740-6  Differential Lock Solenoid: Current Above Normal  Solenoid Valve - Test 
967-9  Machine Application: Abnormal Update Rate  CAN Data Link - Test 
1326-2  ECM Location Code: Data Erratic, Intermittent, or Incorrect  ECM Location Code - Test 
1401- 3  Transmission Solenoid 1: Voltage above normal  Solenoid Valve - Test 
1401- 5  Transmission Solenoid 1: Voltage above normal  Solenoid Valve - Test 
1401- 6  Transmission Solenoid 1: Voltage above normal  Solenoid Valve - Test 
1401- 13  Transmission Solenoid 1: Out of Calibration  Solenoid Valve - Test 
1402- 3  Transmission Solenoid 2: Voltage above normal  Solenoid Valve - Test 
1402- 5  Transmission Solenoid 2: Voltage above normal  Solenoid Valve - Test 
1402- 6  Transmission Solenoid 2: Voltage above normal  Solenoid Valve - Test 
1402- 13  Transmission Solenoid 2: Out of Calibration  Solenoid Valve - Test 
1403- 3  Transmission Solenoid 3: Voltage above normal  Solenoid Valve - Test 
1403- 5  Transmission Solenoid 3: Voltage above normal  Solenoid Valve - Test 
1403- 6  Transmission Solenoid 3: Voltage above normal  Solenoid Valve - Test 
1403- 13  Transmission Solenoid 3: Out of Calibration  Solenoid Valve - Test 
1404- 3  Transmission Solenoid 4: Voltage above normal  Solenoid Valve - Test 
1404- 5  Transmission Solenoid 4: Voltage above normal  Solenoid Valve - Test 
1404- 6  Transmission Solenoid 4: Voltage above normal  Solenoid Valve - Test 
1404- 13  Transmission Solenoid 4: Out of Calibration  Solenoid Valve - Test 
1405- 3  Transmission Solenoid 5: Voltage above normal  Solenoid Valve - Test 
1405- 5  Transmission Solenoid 5: Voltage above normal  Solenoid Valve - Test 
1405- 6  Transmission Solenoid 5: Voltage above normal  Solenoid Valve - Test 
1405- 13  Transmission Solenoid 5: Out of Calibration  Solenoid Valve - Test 
1406- 3  Transmission Solenoid 6: Voltage above normal  Solenoid Valve - Test 
1406- 5  Transmission Solenoid 6: Voltage above normal  Solenoid Valve - Test 
1406- 6  Transmission Solenoid 6: Voltage above normal  Solenoid Valve - Test 
1406- 13  Transmission Solenoid 6: Out of Calibration  Solenoid Valve - Test 
1407- 3  Transmission Solenoid 7: Voltage above normal  Solenoid Valve - Test 
1407- 5  Transmission Solenoid 7: Voltage above normal  Solenoid Valve - Test 
1407- 6  Transmission Solenoid 7: Voltage above normal  Solenoid Valve - Test 
1407- 13  Transmission Solenoid 7: Out of Calibration  Solenoid Valve - Test 
1408- 3  Transmission Solenoid 8: Voltage above normal  Solenoid Valve - Test 
1408- 5  Transmission Solenoid 8: Voltage above normal  Solenoid Valve - Test 
1408- 6  Transmission Solenoid 8: Voltage above normal  Solenoid Valve - Test 
1408- 13  Transmission Solenoid 8: Out of Calibration  Solenoid Valve - Test 
1471- 2  Steering Control Position Sensor #1: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
1471- 3  Steering Control Position Sensor #1: Voltage above normal  Sensor Signal (PWM) - Test 
1471- 4  Steering Control Position Sensor #1: Voltage Below Normal  Sensor Signal (PWM) - Test 
1471- 8  Steering Control Position Sensor #1: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
1471- 14  Steering Control Position Sensor #1: Special Instruction  Sensor Signal (PWM) - Test 
1472- 2  Steering Control Position Sensor #2: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
1472- 3  Steering Control Position Sensor #2: Voltage above normal  Sensor Signal (PWM) - Test 
1472- 4  Steering Control Position Sensor #2: Voltage Below Normal  Sensor Signal (PWM) - Test 
1472- 8  Steering Control Position Sensor #2: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
1472- 14  Steering Control Position Sensor #2: Special Instruction  Sensor Signal (PWM) - Test 
1473- 2  Steering Control Position Sensor #3: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
1473- 3  Steering Control Position Sensor #3: Voltage above normal  Sensor Signal (PWM) - Test 
1473- 4  Steering Control Position Sensor #3: Voltage Below Normal  Sensor Signal (PWM) - Test 
1473- 8  Steering Control Position Sensor #3: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
1473- 14  Steering Control Position Sensor #3: Special Instruction  Sensor Signal (PWM) - Test 
1482-3  10 V Sensor DC Power Supply: Voltage Above Normal  Sensor Supply - Test 
1482-4  10 V Sensor DC Power Supply: Voltage Below Normal  Sensor Supply - Test 
1484-3  Inching Pedal Switch: Voltage Above Normal  Operator Control Switch (Switch To Ground) - Test 
1484-4  Inching Pedal Switch: Voltage Below Normal  Operator Control Switch (Switch To Ground) - Test 
1558-9  Electronic Implement Control #2: Abnormal Update Rate  Cat Data Link - Test 
1558-12  Electronic Implement Control #2: Failure  Cat Data Link - Test 
1558-14  Electronic Implement Control #2: Special Instruction  Cat Data Link - Test 
1674- 3  Solenoid Return #1: Voltage Above Normal  Solenoid Return - Test 
1674-4  Solenoid Return #1: Voltage Below Normal  Solenoid Return - Test 
1674- 5  Solenoid Return #1: Current below normal  Solenoid Return - Test 
2175-3  Secondary Steering System Steer Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2175-5  Secondary Steering System Steer Left Solenoid: Current Below Normal  Solenoid Valve - Test 
2175-6  Secondary Steering System Steer Left Solenoid: Current Above Normal  Solenoid Valve - Test 
2176-3  Secondary Steering System Steer Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2176-5  Secondary Steering System Steer Right Solenoid: Current Below Normal  Solenoid Valve - Test 
2176-6  Secondary Steering System Steer Right Solenoid: Current Above Normal  Solenoid Valve - Test 
2199-3  Secondary Steering Request Signal Line: Voltage Above Normal  Sensor Signal (PWM) - Test 
2199-4  Secondary Steering Request Signal Line: Voltage Below Normal  Sensor Signal (PWM) - Test 
2199-8  Secondary Steering Request Signal Line: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2200-2  Left Steering Cylinder Position Sensor: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2200-3  Left Steering Cylinder Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2200-4  Left Steering Cylinder Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2200-8  Left Steering Cylinder Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2200-14  Left Steering Cylinder Position Sensor: Special Instruction  Sensor Signal (PWM) - Test 
2201-2  Right Steering Cylinder Position Sensor: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2201-3  Right Steering Cylinder Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2201-4  Right Steering Cylinder Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2201-8  Right Steering Cylinder Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2201-14  Right Steering Cylinder Position Sensor: Special Instruction  Sensor Signal (PWM) - Test 
2252-2  Machine Articulation Angle Sensor #2: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2252-3  Machine Articulation Angle Sensor #2: Voltage Above Normal  Sensor Signal (PWM) - Test 
2252-4  Machine Articulation Angle Sensor #2: Voltage Below Normal  Sensor Signal (PWM) - Test 
2252-8  Machine Articulation Angle Sensor #2: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2252-13  Machine Articulation Angle Sensor #2: Out of Calibration  Sensor Signal (PWM) - Test 
2252-14  Machine Articulation Angle Sensor #2: Special Instruction  Sensor Signal (PWM) - Test 
2348-9  SAE J1939 Data Link #2 : Abnormal Update Rate   CAN Data Link - Test  
2348-14  SAE J1939 Data Link #2 : Special Instruction   CAN Data Link - Test  
2742-3  Brake Accumulator Charging Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2742-5  Brake Accumulator Charging Solenoid: Current Below Normal  Solenoid Valve - Test 
2742-6  Brake Accumulator Charging Solenoid: Current Above Normal  Solenoid Valve - Test 
2976-3  Parking Brake Oil Pressure Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2976-4  Parking Brake Oil Pressure Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2976-8  Parking Brake Oil Pressure Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2987-3  Brake Charge Pressure Sensor #1: Voltage Above Normal  Pressure Sensor Signal (PWM) - Test 
2987-4  Brake Charge Pressure Sensor #1: Voltage Below Normal  Pressure Sensor Signal (PWM) - Test 
2987-8  Brake Charge Pressure Sensor #1: Abnormal Frequency, Pulse Width, or Period  Pressure Sensor Signal (PWM) - Test 
2988-3  Brake Charge Pressure Sensor #2: Voltage Above Normal  Pressure Sensor Signal (PWM) - Test 
2988-4  Brake Charge Pressure Sensor #2: Voltage Below Normal  Pressure Sensor Signal (PWM) - Test 
2988-8  Brake Charge Pressure Sensor #2: Abnormal Frequency, Pulse Width, or Period  Pressure Sensor Signal (PWM) - Test 
3035-3  Battery Cable Shield: Voltage Above Normal  Battery Cable Shield - Test 
3035-4  Battery Cable Shield: Voltage Below Normal  Battery Cable Shield - Test 
3210-3  Transmission Pump Bypass Solenoid: Voltage Above Normal  Solenoid Valve - Test 
3210-5  Transmission Pump Bypass Solenoid: Current Below Normal  Solenoid Valve - Test 
3210-6  Transmission Pump Bypass Solenoid: Current Above Normal  Solenoid Valve - Test 
3657-3  Operator In Seat Sensor: Voltage Above Normal  Sensor Signal (Analog, Passive) - Test 
3657-4  Operator In Seat Sensor: Voltage Below Normal  Sensor Signal (Analog, Passive) - Test 
3810-2  Transmission Intermediate Speed Sensor #3: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 

Table 2
All-Wheel Drive ECM (MID 75) 
DTC  Description  Procedure 
41-3  8 VDC Supply: Voltage Above Normal  Sensor Supply - Test 
41-4  8 VDC Supply: Voltage Below Normal  Sensor Supply - Test 
168-2  Electrical System Voltage: Data Erratic, Intermittent, or Incorrect  Electrical Power Supply - Test 
168-3  Electrical System Voltage: Voltage Above Normal  Electrical Power Supply - Test 
168-4  Electrical System Voltage: Voltage Below Normal  Electrical Power Supply - Test 
247-9  SAE J1939 Data Link: Abnormal Update Rate  CAN Data Link - Test 
248-9  Cat Data Link: Abnormal Update Rate  Cat Data Link - Test 
296-9  Transmission Control: Abnormal Update Rate  Cat Data Link - Test 
296-14  Transmission Control: Special Instruction  Cat Data Link - Test 
517-3  All Wheel Drive Switch: Voltage Above Normal  All Wheel Drive System - Test 
517-4  All Wheel Drive Switch: Voltage Below Normal  All Wheel Drive System - Test 
590-9  Engine Control Module: Abnormal Update  Cat Data Link - Test 
590-14  Engine Control Module: Special Instruction  Cat Data Link - Test 
600-3  Hydraulic Oil Temperature Sensor: Voltage Above Normal  Sensor Signal (Analog, Passive) - Test 
600-4  Hydraulic Oil Temperature Sensor: Voltage Below Normal  Sensor Signal (Analog, Passive) - Test 
967-9  Machine Application: Abnormal Update Rate  CAN Data Link - Test 
1326-2  ECM Location Code: Data Erratic, Intermittent, or Incorrect  ECM Location Code - Test 
1558-9  Electronic Implement Control #2: Abnormal Update Rate  Cat Data Link - Test 
1558-14  Electronic Implement Control #2: Special Instruction  Cat Data Link - Test 
2188-3  Left All Wheel Drive (AWD) Clutch Forward Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2188-5  Left All Wheel Drive (AWD) Clutch Forward Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2188-6  Left All Wheel Drive (AWD) Clutch Forward Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2189-3  Left All Wheel Drive (AWD) Clutch Reverse Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2189-5  Left All Wheel Drive (AWD) Clutch Reverse Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2189-6  Left All Wheel Drive (AWD) Clutch Reverse Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2190-3  Right All Wheel Drive (AWD) Clutch Forward Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2190-5  Right All Wheel Drive (AWD) Clutch Forward Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2190-6  Right All Wheel Drive (AWD) Clutch Forward Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2191-3  Right All Wheel Drive (AWD) Clutch Reverse Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2191-5  Right All Wheel Drive (AWD) Clutch Reverse Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2191-6  Right All Wheel Drive (AWD) Clutch Reverse Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2194-3  All Wheel Drive (AWD) Control Dial Position Sensor [MG]: Voltage Above Normal  Sensor Signal (PWM) - Test 
2194-4  All Wheel Drive (AWD) Control Dial Position Sensor [MG]: Voltage Below Normal  Sensor Signal (PWM) - Test 
2194-8  All Wheel Drive (AWD) Control Dial Position Sensor [MG]: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2194-13  All Wheel Drive (AWD) Control Dial Position Sensor [MG]: Out of Calibration  Sensor Signal (PWM) - Test 
2293-3  Left Front Drive Motor Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2293-5  Left Front Drive Motor Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2293-6  Left Front Drive Motor Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2293-13  Left Front Drive Motor Solenoid [MG]: Out of Calibration  Solenoid Valve - Test 
2294-3  Right Front Drive Motor Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2294-5  Right Front Drive Motor Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2294-6  Right Front Drive Motor Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2294-13  Right Front Drive Motor Solenoid [MG]: Out of Calibration  Solenoid Valve - Test 
2295-3  Left Front Drive Pump Forward Control Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2295-5  Left Front Drive Pump Forward Control Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2295-6  Left Front Drive Pump Forward Control Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2295-13  Left Front Drive Pump Forward Control Solenoid [MG]: Out of Calibration  Solenoid Valve - Test 
2296-3  Left Front Drive Pump Reverse Control Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2296-5  Left Front Drive Pump Reverse Control Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2296-6  Left Front Drive Pump Reverse Control Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2296-13  Left Front Drive Pump Reverse Control Solenoid [MG]: Out of Calibration  Solenoid Valve - Test 
2297-3  Right Front Drive Pump Forward Control Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2297-5  Right Front Drive Pump Forward Control Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2297-6  Right Front Drive Pump Forward Control Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2297-13  Right Front Drive Pump Forward Control Solenoid [MG]: Out of Calibration  Solenoid Valve - Test 
2298-3  Right Front Drive Pump Reverse Control Solenoid [MG]: Voltage Above Normal  Solenoid Valve - Test 
2298-5  Right Front Drive Pump Reverse Control Solenoid [MG]: Current Below Normal  Solenoid Valve - Test 
2298-6  Right Front Drive Pump Reverse Control Solenoid [MG]: Current Above Normal  Solenoid Valve - Test 
2298-13  Right Front Drive Pump Reverse Control Solenoid [MG]: Out of Calibration  Solenoid Valve - Test 
2319-2  Left Front Drive Motor Speed Sensor #1: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
2319-14  Left Front Drive Motor Speed Sensor #1: Special Instruction  Speed Sensor - Test 
2320-2  Left Front Drive Motor Speed Sensor #2: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
2320-14  Left Front Drive Motor Speed Sensor #2: Special Instruction  Speed Sensor - Test 
2321-2  Right Front Drive Motor Speed Sensor #1: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
2321-14  Right Front Drive Motor Speed Sensor #1: Special Instruction  Speed Sensor - Test 
2322-2  Right Front Drive Motor Speed Sensor #2: Data Erratic, Intermittent, or Incorrect  Speed Sensor - Test 
2322-14  Right Front Drive Motor Speed Sensor #2: Special Instruction  Speed Sensor - Test 

Table 3
Implement ECM 1 (MID 82) 
DTC  Description  Procedure 
168-2  Electrical System Voltage: Data Erratic, Intermittent, or Incorrect  Electrical Power Supply - Test 
168-3  Electrical System Voltage: Voltage Above Normal  Electrical Power Supply - Test 
168-4  Electrical System Voltage: Voltage Below Normal  Electrical Power Supply - Test 
246-9  Proprietary CAN Data Link: Abnormal Update Rate  CAN Data Link - Test 
247-9  SAE J1939 Data Link: Abnormal Update Rate  CAN Data Link - Test 
248-9  Cat Data Link: Abnormal Update Rate  Cat Data Link - Test 
296-9  Transmission Control: Abnormal Update Rate  Cat Data Link - Test 
296-14  Transmission Control: Special Instruction  Cat Data Link - Test 
297-9  All Wheel Drive Control: Abnormal Update Rate  Cat Data Link - Test 
297-14  All Wheel Drive Control: Special Instruction  Cat Data Link - Test 
358-3  Implement Pilot Pressure Supply Solenoid: Voltage Above Normal  Solenoid Valve - Test 
358-5  Implement Pilot Pressure Supply Solenoid: Current Below Normal  Solenoid Valve - Test 
358-6  Implement Pilot Pressure Supply Solenoid: Current Above Normal  Solenoid Valve - Test 
490-3  Implement Lockout Switch: Voltage Above Normal  Operator Control Switch (Switch To Battery) - Test 
490-4  Implement Lockout Switch: Voltage Below Normal  Operator Control Switch (Switch To Battery) - Test 
590-9  Engine Control Module: Abnormal Update Rate  Cat Data Link - Test 
590-14  Engine Control Module: Special Instruction  Cat Data Link - Test 
600-3  Hydraulic Oil Temperature Sensor: Voltage Above Normal  Sensor Signal (Analog, Passive) - Test 
600-4  Hydraulic Oil Temperature Sensor: Voltage Below Normal  Sensor Signal (Analog, Passive) - Test 
871-9  Inclination Sensor: Abnormal Update Rate  Sensor (Data Link Type) - Test 
908-9  Blade Rotation Position Sensor: Abnormal Update Rate  Sensor (Data Link Type) - Test 
908-13  Blade Rotation Position Sensor: Out of Calibration  Sensor (Data Link Type) - Test 
967-9  Machine Application: Abnormal Update Rate  CAN Data Link - Test 
1326-2  ECM Location Code: Data Erratic, Intermittent, or Incorrect  ECM Location Code - Test 
1482-3  10V DC Sensor Power Supply: Voltage Above Normal  Sensor Supply - Test 
1482-4  10V DC Sensor Power Supply: Voltage Below Normal  Sensor Supply - Test 
1558-9  Electronic Implement Control #2: Abnormal Update Rate  Cat Data Link - Test 
1558-14  Electronic Implement Control #2: Special Instruction  Cat Data Link - Test 
2143-9  Electronic Implement Control #3: Abnormal Update Rate  Cat Data Link - Test 
2143-14  Electronic Implement Control #3: Special Instruction  Cat Data Link - Test 
2150-3  Blade Left Lift Lever Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2150-4  Blade Left Lift Lever Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2150-8  Blade Left Lift Lever Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2151-3  Blade Right Lift Lever Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2151-4  Blade Right Lift Lever Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2151-8  Blade Right Lift Lever Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2152-3  Wheel Lean Control Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2152-4  Wheel Lean Control Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2152-8  Wheel Lean Control Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2153-3  Blade Pitch Control Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2153-4  Blade Pitch Control Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2153-8  Blade Pitch Control Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2154-3  Blade Sideshift Lever Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2154-4  Blade Sideshift Lever Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2154-8  Blade Sideshift Lever Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2155-3  Circle Drive Lever Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2155-4  Circle Drive Lever Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2155-8  Circle Drive Lever Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2156-3  Circle Sideshift Control Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2156-4  Circle Sideshift Control Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2156-8  Circle Sideshift Control Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2160-3  Blade Left Raise Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2160-5  Blade Left Raise Solenoid: Current Below Normal  Solenoid Valve - Test 
2160-6  Blade Left Raise Solenoid: Current Above Normal  Solenoid Valve - Test 
2160-13  Blade Left Raise Solenoid: Out of Calibration  Solenoid Valve - Test 
2161-3  Blade Right Raise Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2161-5  Blade Right Raise Solenoid: Current Below Normal  Solenoid Valve - Test 
2161-6  Blade Right Raise Solenoid: Current Above Normal  Solenoid Valve - Test 
2161-13  Blade Right Raise Solenoid: Out of Calibration  Solenoid Valve - Test 
2162-3  Blade Left Lower Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2162-5  Blade Left Lower Solenoid: Current Below Normal  Solenoid Valve - Test 
2162-6  Blade Left Lower Solenoid: Current Above Normal  Solenoid Valve - Test 
2162-13  Blade Left Lower Solenoid: Out of Calibration  Solenoid Valve - Test 
2163-3  Blade Right Lower Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2163-5  Blade Right Lower Solenoid: Current Below Normal  Solenoid Valve - Test 
2163-6  Blade Right Lower Solenoid: Current Above Normal  Solenoid Valve - Test 
2163-13  Blade Right Lower Solenoid: Out of Calibration  Solenoid Valve - Test 
2165-3  Blade Sideshift Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2165-5  Blade Sideshift Left Solenoid: Current Below Normal  Solenoid Valve - Test 
2165-6  Blade Sideshift Left Solenoid: Current Above Normal  Solenoid Valve - Test 
2165-13  Blade Sideshift Left Solenoid: Out of Calibration  Solenoid Valve - Test 
2166-3  Blade Sideshift Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2166-5  Blade Sideshift Right Solenoid: Current Below Normal  Solenoid Valve - Test 
2166-6  Blade Sideshift Right Solenoid: Current Above Normal  Solenoid Valve - Test 
2166-13  Blade Sideshift Right Solenoid: Out of Calibration  Solenoid Valve - Test 
2167-3  Circle Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2167-5  Circle Left Solenoid: Current Below Normal  Solenoid Valve - Test 
2167-6  Circle Left Solenoid: Current Above Normal  Solenoid Valve - Test 
2167-13  Circle Left Solenoid: Out of Calibration  Solenoid Valve - Test 
2168-3  Circle Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2168-5  Circle Right Solenoid: Current Below Normal  Solenoid Valve - Test 
2168-6  Circle Right Solenoid: Current Above Normal  Solenoid Valve - Test 
2168-13  Circle Right Solenoid: Out of Calibration  Solenoid Valve - Test 
2169-3  Circle Sideshift Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2169-5  Circle Sideshift Left Solenoid: Current Below Normal  Solenoid Valve - Test 
2169-6  Circle Sideshift Left Solenoid: Current Above Normal  Solenoid Valve - Test 
2169-13  Circle Sideshift Left Solenoid: Out of Calibration  Solenoid Valve - Test 
2170-3  Circle Sideshift Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2170-5  Circle Sideshift Right Solenoid: Current Below Normal  Solenoid Valve - Test 
2170-6  Circle Sideshift Right Solenoid: Current Above Normal  Solenoid Valve - Test 
2170-13  Circle Sideshift Right Solenoid: Out of Calibration  Solenoid Valve - Test 
2173-3  Wheel Lean Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2173-5  Wheel Lean Left Solenoid: Current Below Normal  Solenoid Valve - Test 
2173-6  Wheel Lean Left Solenoid: Current Above Normal  Solenoid Valve - Test 
2173-13  Wheel Lean Left Solenoid: Out of Calibration  Solenoid Valve - Test 
2174-3  Wheel Lean Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2174-5  Wheel Lean Right Solenoid: Current Below Normal  Solenoid Valve - Test 
2174-6  Wheel Lean Right Solenoid: Current Above Normal  Solenoid Valve - Test 
2174-13  Wheel Lean Right Solenoid: Out of Calibration  Solenoid Valve - Test 
2181-3  Blade Pitch Forward Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2181-5  Blade Pitch Forward Solenoid: Current Below Normal  Solenoid Valve - Test 
2181-6  Blade Pitch Forward Solenoid: Current Above Normal  Solenoid Valve - Test 
2181-13  Blade Pitch Forward Solenoid: Out of Calibration  Solenoid Valve - Test 
2182-3  Blade Pitch Backward Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2182-5  Blade Pitch Backward Solenoid: Current Below Normal  Solenoid Valve - Test 
2182-6  Blade Pitch Backward Solenoid: Current Above Normal  Solenoid Valve - Test 
2182-13  Blade Pitch Backward Solenoid: Out of Calibration  Solenoid Valve - Test 
2204-3  Auxiliary Lever #1 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2204-4  Auxiliary Lever #1 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2204-8  Auxiliary Lever #1 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2205-3  Auxiliary Lever #2 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2205-4  Auxiliary Lever #2 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2205-8  Auxiliary Lever #2 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2206-3  Auxiliary Lever #3 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2206-4  Auxiliary Lever #3 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2206-8  Auxiliary Lever #3 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2207-3  Auxiliary Lever #4 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2207-4  Auxiliary Lever #4 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2207-8  Auxiliary Lever #4 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2208-3  Auxiliary Lever #5 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2208-4  Auxiliary Lever #5 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2208-8  Auxiliary Lever #5 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2209-3  Auxiliary Lever #6 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2209-4  Auxiliary Lever #6 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2209-8  Auxiliary Lever #6 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2210-3  Auxiliary Lever #7 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2210-4  Auxiliary Lever #7 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2210-8  Auxiliary Lever #7 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2211-3  Auxiliary Valve #1 Port B Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2211-5  Auxiliary Valve #1 Port B Solenoid: Current Below Normal  Solenoid Valve - Test 
2211-6  Auxiliary Valve #1 Port B Solenoid: Current Above Normal  Solenoid Valve - Test 
2211-13  Auxiliary Valve #1 Port B Solenoid: Out of Calibration  Solenoid Valve - Test 
2212-3  Auxiliary Valve #1 Port A Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2112-5  Auxiliary Valve #1 Port A Solenoid: Current Below Normal  Solenoid Valve - Test 
2212-6  Auxiliary Valve #1 Port A Solenoid: Current Above Normal  Solenoid Valve - Test 
2212-13  Auxiliary Valve #1 Port A Solenoid: Out of Calibration  Solenoid Valve - Test 
2113-3  Auxiliary Valve #2 Port B Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2213-5  Auxiliary Valve #2 Port B Solenoid: Current Below Normal  Solenoid Valve - Test 
2213-6  Auxiliary Valve #2 Port B Solenoid: Current Above Normal  Solenoid Valve - Test 
2213-13  Auxiliary Valve #2 Port B Solenoid: Out of Calibration  Solenoid Valve - Test 
2214-3  Auxiliary Valve #2 Port A Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2214-5  Auxiliary Valve #2 Port A Solenoid: Current Below Normal  Solenoid Valve - Test 
2214-6  Auxiliary Valve #2 Port A Solenoid: Current Above Normal  Solenoid Valve - Test 
2214-13  Auxiliary Valve #2 Port A Solenoid: Out of Calibration  Solenoid Valve - Test 
2215-3  Auxiliary Valve 3 Port B Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2215-5  Auxiliary Valve 3 Port B Solenoid: Current Below Normal  Solenoid Valve - Test 
2215-6  Auxiliary Valve 3 Port B Solenoid: Current Above Normal  Solenoid Valve - Test 
2216-3  Auxiliary Valve 3 Port A Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2216-5  Auxiliary Valve 3 Port A Solenoid: Current Below Normal  Solenoid Valve - Test 
2216-6  Auxiliary Valve 3 Port A Solenoid: Current Above Normal  Solenoid Valve - Test 
2217-3  Auxiliary Valve 4 Port B Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2217-5  Auxiliary Valve 4 Port B Solenoid: Current Below Normal  Solenoid Valve - Test 
2217-6  Auxiliary Valve 4 Port B Solenoid: Current Above Normal  Solenoid Valve - Test 
2218-3  Auxiliary Valve 4 Port A Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2218-5  Auxiliary Valve 4 Port A Solenoid: Current Below Normal  Solenoid Valve - Test 
2218-6  Auxiliary Valve 4 Port A Solenoid: Current Above Normal  Solenoid Valve - Test 
2219-3  Auxiliary Valve 5 Port B Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2219-5  Auxiliary Valve 5 Port B Solenoid: Current Below Normal  Solenoid Valve - Test 
2219-6  Auxiliary Valve 5 Port B Solenoid: Current Above Normal  Solenoid Valve - Test 
2220-3  Auxiliary Valve 5 Port A Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2220-5  Auxiliary Valve 5 Port A Solenoid: Current Below Normal  Solenoid Valve - Test 
2220-6  Auxiliary Valve 5 Port A Solenoid: Current Above Normal  Solenoid Valve - Test 
2221-3  Auxiliary Valve 6 Port B Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2221-5  Auxiliary Valve 6 Port B Solenoid: Current Below Normal  Solenoid Valve - Test 
2221-6  Auxiliary Valve 6 Port B Solenoid: Current Above Normal  Solenoid Valve - Test 
2222-3  Auxiliary Valve 6 Port A Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2222-5  Auxiliary Valve 6 Port A Solenoid: Current Below Normal  Solenoid Valve - Test 
2222-6  Auxiliary Valve 6 Port A Solenoid: Current Above Normal  Solenoid Valve - Test 
2258-3  Left Blade Control Mode Switch: Voltage Above Normal  Operator Control Switch (Switch to Ground) - Test 
2258-4  Left Blade Control Mode Switch: Voltage Below Normal  Operator Control Switch (Switch to Ground) - Test 
2259-3  Right Blade Control Mode Switch: Voltage Above Normal  Operator Control Switch (Switch to Ground) - Test 
2259-4  Right Blade Control Mode Switch: Voltage Below Normal  Operator Control Switch (Switch to Ground) - Test 
2260-3  Side Shift Blade Control Mode Switch: Voltage Above Normal  Operator Control Switch (Switch to Ground) - Test 
2260-4  Side Shift Blade Control Mode Switch: Voltage Below Normal  Operator Control Switch (Switch to Ground) - Test 
2261-2  Left Desired Grade Offset Switch: Data Erratic, Intermittent, or Incorrect  Operator Control Switch (Switch to Ground) - Test

For ACJ Thumbwheel, go to Sensor Signal (PWM) - Test 
2261-3  Left Desired Grade Offset Switch: Voltage Above Normal  Operator Control Switch (Switch to Ground) - Test

For ACJ Thumbwheel, go to Sensor Signal (PWM) - Test 
2261-4  Left Desired Grade Offset Switch: Voltage Below Normal  Operator Control Switch (Switch to Ground) - Test

For ACJ Thumbwheel, go to Sensor Signal (PWM) - Test 
2262-2  Right Desired Grade Offset Switch: Data Erratic, Intermittent, or Incorrect  Operator Control Switch (Switch to Ground) - Test

For ACJ Thumbwheel, go to Sensor Signal (PWM) - Test 
2262-3  Right Desired Grade Offset Switch: Voltage Above Normal  Operator Control Switch (Switch to Ground) - Test

For ACJ Thumbwheel, go to Sensor Signal (PWM) - Test 
2262-4  Right Desired Grade Offset Switch: Voltage Below Normal  Operator Control Switch (Switch to Ground) - Test

For ACJ Thumbwheel, go to Sensor Signal (PWM) - Test 
2954-14  Unknown Electronic Implement Control: Special Instruction  ECM Location Code - Test 
3423-13  Grade Control System: Out of Calibration  Sensor (Data Link Type) - Test 
3694-9  Blade Slope Sensor: Abnormal Update Rate  Sensor (Data Link Type) - Test 
3694-13  Blade Slope Sensor: Out of Calibration  Sensor (Data Link Type) - Test 
3797-3  Operator Seat Belt Switch: Voltage Above Normal  Operator Control Switch (Switch to Ground) - Test 
3797-4  Operator Seat Belt Switch: Voltage Below Normal  Operator Control Switch (Switch to Ground) - Test 
4386-3  Auxiliary Lever #8 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
4386-4  Auxiliary Lever #8 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
4386-8  Auxiliary Lever #8 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
4387-3  Auxiliary Lever #9 Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
4387-4  Auxiliary Lever #9 Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
4387-8  Auxiliary Lever #9 Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 

Table 4
Implement (Steering) ECM 2 (MID 145) 
DTC  Description  Procedure 
41-3  8 VDC Supply: Voltage Above Normal  Sensor Supply - Test 
41-4  8 VDC Supply: Voltage Below Normal  Sensor Supply - Test 
75-3  Steering Oil Temperature Sensor: Voltage Above Normal  Sensor Signal (Analog, Passive) - Test 
75-4  Steering Oil Temperature Sensor: Voltage Below Normal  Sensor Signal (Analog, Passive) - Test 
168-2  Electrical System Voltage: Data Erratic, Intermittent, or Incorrect  Electrical Power Supply - Test 
168-3  Electrical System Voltage: Voltage Above Normal  Electrical Power Supply - Test 
168-4  Electrical System Voltage: Voltage Below Normal  Electrical Power Supply - Test 
247-9  SAE J1939 Data Link: Abnormal Update Rate  CAN Data Link - Test 
248-9  Cat Data Link: Abnormal Update Rate  Cat Data Link - Test 
262-3  5 V Sensor DC Power Supply: Voltage Above Normal  Sensor Supply - Test 
262-4  5 V Sensor DC Power Supply: Voltage Below Normal  Sensor Supply - Test 
296-9  Transmission Control: Abnormal Update Rate  Cat Data Link - Test 
296-12  Transmission Control: Bad Device or component  Cat Data Link - Test 
296-14  Transmission Control: Special Instruction  Cat Data Link - Test 
297-9  All Wheel Drive Control: Abnormal Update Rate  Cat Data Link - Test 
297-14  All Wheel Drive Control: Special Instruction  Cat Data Link - Test 
590-9  Engine Control Module: Abnormal Update Rate  Cat Data Link - Test 
590-14  Engine Control Module: Special Instruction  Cat Data Link - Test 
596-9  Implement Control Module: Abnormal Update Rate  Cat Data Link - Test 
596-14  Implement Control Module: Special Instruction  Cat Data Link - Test 
615-2  Machine Articulation Angle Sensor: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
615-3  Machine Articulation Angle Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
615-4  Machine Articulation Angle Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
615-8  Machine Articulation Angle Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
615-13  Machine Articulation Angle Sensor: Out of Calibration  Sensor Signal (PWM) - Test 
615-14  Machine Articulation Angle Sensor: Special Instruction  Sensor Signal (PWM) - Test 
967-9  Machine Application: Abnormal Update Rate  CAN Data Link - Test 
1326-2  ECM Location Code: Data Erratic, Intermittent, or Incorrect  ECM Location Code - Test 
1471-2  Steering Control Position Sensor #1: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
1471-3  Steering Control Position Sensor #1: Voltage Above Normal  Sensor Signal (PWM) - Test 
1471-4  Steering Control Position Sensor #1: Voltage Below Normal  Sensor Signal (PWM) - Test 
1471-8  Steering Control Position Sensor #1: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
1471-14  Steering Control Position Sensor #1: Special Instruction  Sensor Signal (PWM) - Test 
1472-2  Steering Control Position Sensor #2: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
1472-3  Steering Control Position Sensor #2: Voltage Above Normal  Sensor Signal (PWM) - Test 
1472-4  Steering Control Position Sensor #2: Voltage Below Normal  Sensor Signal (PWM) - Test 
1472-8  Steering Control Position Sensor #2: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
1472-14  Steering Control Position Sensor #2: Special Instruction  Sensor Signal (PWM) - Test 
1473-2  Steering Control Position Sensor #3: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
1473-3  Steering Control Position Sensor #3: Voltage Above Normal  Sensor Signal (PWM) - Test 
1473-4  Steering Control Position Sensor #3: Voltage Below Normal  Sensor Signal (PWM) - Test 
1473-8  Steering Control Position Sensor #3: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
1473-14  Steering Control Position Sensor #3: Special Instruction  Sensor Signal (PWM) - Test 
1482-3  10 V Sensor DC Power Supply: Voltage Above Normal  Sensor Supply - Test 
1482-4  10 V Sensor DC Power Supply: Voltage Below Normal  Sensor Supply - Test 
1674-3  Solenoid Return #1: Voltage Above Normal  Solenoid Return - Test 
1674-4  Solenoid Return #1: Voltage Below Normal  Solenoid Return - Test 
1674-5  Solenoid Return #1: Current Below Normal  Solenoid Return - Test 
1960-9  Key Reader: Abnormal Update Rate  Cat Data Link - Test 
2146-2  Articulation Lever Position Sensor: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2146-3  Articulation Lever Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2146-4  Articulation Lever Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2146-8  Articulation Lever Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2147-3  Automatic Neutral Articulation Switch: Voltage Above Normal  Switch Circuits - Test 
2147-4  Automatic Neutral Articulation Switch: Voltage Below Normal  Switch Circuits - Test 
2171-3  Articulate Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2171-5  Articulate Left Solenoid: Current Below Normal  Solenoid Valve - Test 
2171-6  Articulate Left Solenoid: Current Above Normal  Solenoid Valve - Test 
2171-13  Articulate Left Solenoid: Out of Calibration  Solenoid Valve - Test 
2172-3  Articulate Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2172-5  Articulate Right Solenoid: Current Below Normal  Solenoid Valve - Test 
2172-6  Articulate Right Solenoid: Current Above Normal  Solenoid Valve - Test 
2172-13  Articulate Right Solenoid: Out of Calibration  Solenoid Valve - Test 
2177-3  Primary Steering Disable Solenoid: Voltage Above Normal  Solenoid Valve - Test 
2177-5  Primary Steering Disable Solenoid: Current Below Normal  Solenoid Valve - Test 
2177-6  Primary Steering Disable Solenoid: Current Above Normal  Solenoid Valve - Test 
2200-2  Left Steering Cylinder Position Sensor: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2200-3  Left Steering Cylinder Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2200-4  Left Steering Cylinder Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2200-8  Left Steering Cylinder Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2200-14  Left Steering Cylinder Position Sensor: Special Instruction  Sensor Signal (PWM) - Test 
2201-2  Right Steering Cylinder Position Sensor: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2201-3  Right Steering Cylinder Position Sensor: Voltage Above Normal  Sensor Signal (PWM) - Test 
2201-4  Right Steering Cylinder Position Sensor: Voltage Below Normal  Sensor Signal (PWM) - Test 
2201-8  Right Steering Cylinder Position Sensor: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2201-14  Right Steering Cylinder Position Sensor: Special Instruction  Sensor Signal (PWM) - Test 
2203-3  Primary Steering Valve Spool Displacement Signal Line: Voltage Above Normal  Sensor Signal (Analog, Active) - Test 
2203-4  Primary Steering Valve Spool Displacement Signal Line: Voltage Below Normal  Sensor Signal (Analog, Active) - Test 
2252-2  Machine Articulation Angle Sensor #2: Data Erratic, Intermittent, or Incorrect  Sensor Signal (PWM) - Test 
2252-3  Machine Articulation Angle Sensor #2: Voltage Above Normal  Sensor Signal (PWM) - Test 
2252-4  Machine Articulation Angle Sensor #2: Voltage Below Normal  Sensor Signal (PWM) - Test 
2252-8  Machine Articulation Angle Sensor #2: Abnormal Frequency, Pulse Width, or Period  Sensor Signal (PWM) - Test 
2252-13  Machine Articulation Angle Sensor #2: Out of Calibration  Sensor Signal (PWM) - Test 
2466-9  Engine Aftertreatment Control #1: Abnormal Update Rate  Cat Data Link - Test 
2466-14  Engine Aftertreatment Control #1: Special Instruction  Cat Data Link - Test 
2828-3  Main Hydraulic Pump Pressure Sensor #1: Voltage Above Normal  Sensor Signal (Analog, Active) - Test 
2828-4  Main Hydraulic Pump Pressure Sensor #1: Voltage Below Normal  Sensor Signal (Analog, Active) - Test 
2828-14  Main Hydraulic Pump Pressure Sensor #1: Special Instruction  Sensor Signal (Analog, Active) - Test 
2829-2  Main Hydraulic Pump Pressure Sensor #2: Data Erratic, Intermittent, or Incorrect  Pressure Sensor Signal (PWM) - Test 
2829-3  Main Hydraulic Pump Pressure Sensor #2: Voltage Above Normal  Pressure Sensor Signal (PWM) - Test 
2829-4  Main Hydraulic Pump Pressure Sensor #2: Voltage Below Normal  Pressure Sensor Signal (PWM) - Test 
2829-8  Main Hydraulic Pump Pressure Sensor #2: Abnormal Frequency, Pulse Width, or Period  Pressure Sensor Signal (PWM) - Test 
2829-14  Main Hydraulic Pump Pressure Sensor #2: Special Instruction  Pressure Sensor Signal (PWM) - Test 
3284-3  Primary Steering System Steer Left Solenoid: Voltage Above Normal  Solenoid Valve - Test 
3284-5  Primary Steering System Steer Left Solenoid: Current Below Normal  Solenoid Valve - Test 
3284-6  Primary Steering System Steer Left Solenoid: Current Above Normal  Solenoid Valve - Test 
3284-13  Primary Steering System Steer Left Solenoid: Out of Calibration  Solenoid Valve - Test 
3285-3  Primary Steering System Steer Right Solenoid: Voltage Above Normal  Solenoid Valve - Test 
3285-5  Primary Steering System Steer Right Solenoid: Current Below Normal  Solenoid Valve - Test 
3285-6  Primary Steering System Steer Right Solenoid: Current Above Normal  Solenoid Valve - Test 
3285-13  Primary Steering System Steer Right Solenoid: Out of Calibration  Solenoid Valve - Test 
3895-2  Automatic Articulation Mode Switch: Data Erratic, Intermittent, or Incorrect  Switch Circuits - Test 
3895-3  Automatic Articulation Mode Switch: Voltage Above Normal  Switch Circuits - Test 
3895-4  Automatic Articulation Mode Switch: Voltage Below Normal  Switch Circuits - Test 

Table 5
Implement ECM 3 (MID 147) 
DTC  Description  Procedure 
168-2  Electrical System Voltage: Data Erratic, Intermittent, or Incorrect  Electrical Power Supply - Test 
168-3  Electrical System Voltage: Voltage Above Normal  Electrical Power Supply - Test 
168-4  Electrical System Voltage: Voltage Below Normal  Electrical Power Supply - Test 
1326-2  ECM Location Code: Data Erratic, Intermittent, or Incorrect  ECM Location Code - Test 

Information System:

Three60 Precision Control System Configuration Parameters
C13 and C15 Generator Sets Refill Capacities
Installation Procedure For The Improved 377-2167 Water Lines Gp {1380}
2013/10/31 Improved Water Lines Group For Certain G3520B Engines {1380}
2013/11/13 Cylinder Head Gasket Torque Procedures for Certain 3500 Engines {1100, 1124}
2013/11/12 Cylinder Head Gasket Torque Procedures for Certain3500 Machine Engines {1100, 1124}
C32 Marine Generator Set Maintenance Interval Schedule
C9 Petroleum Engine Fluid Recommendations
C9 Petroleum Engine Refill Capacities
Inspection Criteria for MMUs Experiencing Load Cell - CM Errors{4480}
XQC1200 Power Module Before Starting Engine
XQC1600 Power Module Electronic Modular Control Panel 4 (EMCP 4)
C4.4 Industrial Engine Coolant (ELC) - Change
2014/01/13 New Jacket Water Heater Groups Are Used on Certain 3500 Engines {1383}
794 AC, 796 AC, and 798 AC Off-Highway Truck Electronic Control System Diagnostic Trouble Codes
3512B and 3516B Generator Set Engines with Dynamic Gas Blending Water Temperature Regulator
2013/12/10 A New Cable Assembly for the Powered Access Stairway Is Now Used on Certain Off-Highway Trucks {7254}
Procedure for Removing and Installing the Exhaust Cooler (NRS) on All Tier 4 C15 and C18 Engines {108C, 108G}
3512B and 3516B Generator Set Engines with Dynamic Gas Blending Radiator
2013/10/24 New Software for the Turbocharger Protection Strategy on the C4.4 Engine {1052, 1920}
3512B and 3516B Generator Set Engines with Dynamic Gas Blending Air Shutoff
2013/11/04 New Procedure for Mounting Space Heater Is Now Available for Certain Cat Engines and Generator Sets {4450}
12M Series 3, 140M Series 3, 160M Series 3, 140, 150 and and 160 Motor Graders Control Manifold (Brake)
12M Series 3, 140M Series 3, 160M Series 3, 140, 150 and and 160 Motor Graders Control Manifold (Hydraulic Fan)